Caterpillar Engines Troubleshooting

Cat Engines Maintenance & Repair Guides

Skip to content
Menu
  • Home
  • About Me
  • Contact Us
  • Privacy Policy

Tag: heater

3126

3100 HEUI Diesel Truck Engine Inlet Air Heater

Posted on July 24, 2017 by sam

To aid starting and prevent white smoke emission at start up, the engines are equipped with an electric heater located at the air inlet casting.…

3126

3100 HEUI Diesel Truck Engine Fuel Heater And Water Separator

Posted on July 24, 2017 by sam

(1) Fuel inlet. (2) Fuel filter. (3) Fuel outlet. (4) Base. (5) Heater. (6) Temperature sensor. (7) Drain valve. Some engines may have a combination…

3126

3116 and 3126 Truck Engines Air Inlet Heater Solenoid – Remove and Install

Posted on July 22, 2017 by sam

Removal Procedure Illustration 1 g00629847 Note: The air inlet heater solenoid is located just above the turbocharger on the air inlet manifold. 1.Disconnect harness assembly…

3126

3116 and 3126 Truck Engines Air Inlet Heater – Remove and Install

Posted on July 22, 2017 by sam

Removal Procedure Illustration 1 g00644927 1.Disconnect the hoses from air inlet elbows (5) . 2.Disconnect harness assembly (1) from air inlet heater (2) . 3.Remove…

3126

3116 and 3126 Truck Engines Inlet Air Heater

Posted on July 22, 2017July 22, 2017 by sam

Section View Of Heater Assembly (Dual Tube Inlet Manifold) (1) Heater assembly. (2) Tighten nut to a torque of … 13 ± 1 N·m (10…

3126

3100 HEUI Troubleshooting Inlet Air Heater Circuit Test

Posted on July 21, 2017 by sam

System Operation Schematic ECM Pin Locations Diagnostic Codes Inlet Air Heater Operation Chart (Personality Modules before JUN97) Inlet Air Heater Operation Chart (JUN97 and later…

Resources

  • About Me
  • Contact Us
  • Privacy Policy

Categories

  • 3126
  • 3126
  • 3208
  • 3306
  • 3406E
  • BX-2150
  • C15
  • C18
  • C7
  • Cat ID
  • D330
  • Delco 27SI
  • EL-740
  • Engine News
  • Programming
  • Service Magazine
  • Special Instruction
  • Troubleshooting
  • Uncategorized

Recent Posts

  • Programming – A/C Pressure Switch Fan-On Time
  • Programming – Minimum & Maximum Idle Shutdown Outside Temperature
  • Programming – Allow Idle Shutdown Override
  • Programming – Idle Shutdown Timer
  • Programming – Governor Type
© Copyright 2025 – Caterpillar Engines Troubleshooting
Wisteria Theme by WPFriendship ⋅ Powered by WordPress

Privacy Policy